Pharmaceutical heating 1000l industrial water bath reactor with boiler steam is how the selection of modern pharmaceutical companies to produce an important source of power. Main steam as a heat transfer medium, are widely used in heating and heating. Chinese medicine and its preparation extraction, concentration, dissolution, drying, sterilization, disinfection, heating, humidification, etc. should be widely applied. 1. How to choose type of boiler meet the technical requirements of the pharmaceutical production process, is an important factor affecting the normal operation of the modern pharmaceutical companies. Pharmaceutical companies not only need to be heated in the production process, also need to provide heating for the air-conditioning equipment. Clean air-conditioning systems not only need heating in winter, but also to raise the temperature of the air conditioning units in the summer after cooling, cooling and dehumidification, temperature and humidity to ensure a clean area. Major pharmaceutical companies for use in process heating, sterilization, washing, in addition to air conditioning, refrigeration, heating and the like.

In addition, in the "1000l industrial water bath reactor with boiler Disable Report" of specific content, there is a major business name, boiler number, registration number and boiler boiler type, number of units and the intended use of these. Also, specify the reason for the shutdown, as well as security measures of boiler shutdown, these two, is indispensable. 2. What is the grate-fired boilers? What are its specific in the past? Layer burning boiler, which is a boiler that from a professional standpoint, it refers to a boiler fuel which is on the combustion grate. As for the specific type thereof, there are mainly the following four, are as follows: Category One: layer burning fuel bed boilers and moving grate are not, such as hand burning fixed grate boiler. Two types: fixed grate-fired boilers, but the fuel level layer of the mobile, such as tilting grate boiler, the boiler feed type grate. Category III: the mobile grate the fuel bed, but immobile layer fired boilers, such as throwing coal stove. Four types: the fuel bed and the grate-fired boilers are moved layers, such as chain furnace.

Features 1000l industrial water bath reactor with boiler during operation of the drum 1. The composition of operating pressures and gas turbine combined cycle steam boiler blowdown waste heat boiler has two or three drum, each drum minutes, run at different pressures, such as boilers combination of three steam drum, the drum has a pressure of a pressure drum, a low-pressure drum. In addition to the low pressure steam low pressure steam into the drum is not generated and the steam turbine into the deaerator, the high pressure steam supply to the steam drum Du machine. Qian any type of boiler, such as the presence or steam separator drum level fault, will produce serious chemical injury; for multi-component waste heat boiler drum, Q will be more serious. Further, in order to save water and energy transfer, sewage discharge way from the upper drum to the lower drum, and chemical changes affect the other drum in a steam drum. 2. Only water wall tube number 1 is set in the conventional exhaust heat recovery boiler waterwall tubes, the tubes can absorb heat due to the surrounding child, the cold side of the hot-side heat conditions conventional boiler waterwall tubes absent. On the other hand the flue gas flow, boiler, different heat flux and heat flux at the last row of finned tube of the first row at the finned tube, the difference was greater at startup. Typically, the first row of fins flue gas stream corresponds to the riser pipe, finned tube corresponds to the last row of the downcomer. However, the temperature rise in the boiler startup phase, as yet supplied to the steam turbine, the flue gas flow tuna rearmost tube sheet may be reversed, so that it corresponds to the initial rise in concentration of the chemical composition should be low, which allows the wall the resulting precipitate was minimal. 3. In addition to the waste heat boiler of the gas turbine combined cycle, oxygen is an important part of the low-pressure steam drum. Typically, low pressure steam into the low pressure steam generated by the drum deaerator feed water and makeup water to provide resources, as alternate start boiler is not provided, so that if the outlet steam pressure boiler system deaerator and the deaerator at start when open to the atmosphere, stop shutdown, the water tank to absorb oxygen, oxygen dissolved in water combined cycle heat recovery boiler causes pitting and fatigue corrosion. 4. The waste heat boiler because the DC current is no waste heat boiler drum, economizer nor evaporator superheater, when water flows through the tube bundle, the position of the interface is dependent on water vapor partial pressure of the water flow and heat absorption. 5. Run peaking gas turbine waste heat boiler can be designed to start and stop frequently, with a peak load operation, the situation in the future, peak load operation with frequent starts and stops often appear. But many ask the waste heat boiler with frequent stops the unit is related to the waste heat boiler difficult to adapt to frequent starts and stops with the state of the peak-load operation, the waste heat boiler operating status will cause a large thermal stress and chemical corrosion. These are the boiler equipment produced in the course of their work which reaction: inside equipment parts need to pay more attention, are carefully marked out.

February 20, 2019, the Beijing Municipal Government issued the "Beijing's pollution prevention campaign of 2019 Action Plan" (hereinafter referred to as the "Action Plan"). "Action Plan" clearly 2019 development goals: the first is the city PM2.5年均浓度, three-year moving average concentration strive to continue to decline.

Since 2018 autumn and winter, fog and haze in control efforts continue to increase. Beijing, Tianjin Fenwei Plain, the Yangtze River Delta region of the focus of supervision and maintain a high pressure situation, provinces and cities have also introduced Blue Sky Battle plan, air pollution control sector welcome the opportunity. And because the 2018 autumn and winter abolition of green "one size fits all", so that pollution from the administrative means to switch to environmentally friendly means to speed up environmental protection business orders release.

"Winning Blue Sky Battle three-year action plan" called for increased efforts to eliminate small coal-fired boilers, the county level and above urban area basically eliminated 10 tons of steam per hour and coal-fired boilers, in principle, to the new 35 per hour tons of steam coal-fired boilers. We believe that, under constant fog and haze, the small boiler phase-out process will accelerate. Research believes that by 2021 the transformation of coal-fired central heating investment 88.6 billion yuan, annual operating income of 240 billion yuan, the central heating market will also speed up the release with the environmental supervision.

Professionals expect non-electric air control about 192.2 billion market space, ultra-low emission thermal power market reform space of about 65.7 billion yuan, the whole vast air pollution control requirements.

In addition, the high diesel vehicle emissions, is also one of the main source of haze pollution. Considering the number of ministries had jointly issued by the Ministry of Ecology and environment "diesel truck pollution control tough fight Action Plan" diesel vehicles, boats become the focus of the next step of action to win the Battle of the blue sky.