5 ton boiler used for paper industry
Such as hotels, winter heating and summer just for sanitary hot water, if the total load of the 5 ton boiler used for paper industry to the election, then the summer only for hot water in the shower, the boiler operating load is very low, the efficiency drops. It should first calculate the thermal load of each use, and then performs the selection based on usage and other capacity, such systems investment savings, the system is simple, good mutual support. In addition to the kitchen, laundry, pasteurized and winter air humidification steam must heat load, the remaining load should heat source hot water boiler. 3, choose steam boiler or hot water boiler?
Utility 5 ton boiler used for paper industry technology
At the completion of the city's foundation 10 steam tons / hour and the coal-fired 5 ton boiler used for paper industry Chaigai, and gradually expand the coal-fired boiler demolition and clean energy transformation range, before the end of 2020, the city planning area basically eliminated 35 tons of steam / coal-fired and boiler.
Xinyang, Henan decreasing year by year funding award boiler fill ways:
(1) the completion of the coal-fired boiler Chaigai before the end of October 2018, giving not less than 60,000 yuan / tons of steam financial awards complement;
(2) the completion of the coal-fired boiler Chaigai before the end of October 2019, giving not less than 40,000 yuan / tons of steam financial awards complement;
(3) complete Chaigai coal-fired boilers for the end of October 2020, the prize money will not give up.
At present, many City in Henan Province have been put forward relevant atmospheric Prevention Act, because the policy has landed Henan Province, allowances and Chaigai range of boiler Metro Toronto are the same.
First, the gas 5 ton boiler used for paper industry energy-saving operation of the principal contradiction exists
Required for combustion of combustible materials in addition to gas, but also sufficient oxygen, oxygen is mainly from the air. In addition, a sufficiently high temperature is essential. In general, the combustion conditions comprises: a proportion of combustible material, oxygen molecules and a certain temperature. The energy conservation law, the release of gas entering the boiler system total energy q, should be equal to the total energy flowing from the boiler system comprising a furnace heat absorption water q1, bad water absorption cycle heat q2, loss of incomplete combustion Q3, Q4 heat, smoke q5. That is: q = q1 + q2 + q3 + q4 + q5.