condensing hot water boilers ecomfort
"Euromonitor" closed series of boiler condensate recovery system, the condensed water directly into the boiler temperature, with three-pass boiler air preheater + + economizer, full use of the flue gas heat recovery and then the temperature condensate from the source use, reducing energy waste and significant cost savings for businesses, the effect is immediate.
Heating boiler superheater heating stove maintenance process for a predetermined maintenance process for a predetermined superheater: compressed air on the other in the flow direction of flue gas external superheater fouling, for not blow clean hard scratch-off of fouling. When the sootblowing start the induced draft fan, open the appropriate opening degree of the damper flap. In each overhaul of superheater tubes should abrasion etc. inspection and expanding the crude, the crude by measuring the degree of expansion card superheater, exceeds the standard should be replaced with new pipes, a degree of wear of the caliper measurement superheater, exceeds the standard by replace with new tube, to check visually the superheater tubes, light or the like the degree of curvature drawn wire, bent beyond the standard should be corrected or new ones, after the inspection and make a record.
Why low nitrogen boiler? Referred to this issue, I believe we all understand the importance of low nitrogen boiler, in response to the strong support of the national environmental policy call, more and more manufacturers are choosing low-nitrogen boiler to replace the previous old equipment, and for those emission targets exceeded factories and enterprises, the state is stepped up efforts to punish and suspend business for rectification uncommon, has become the norm, therefore, despite the high cost of low nitrogen boiler, but for long-term development of enterprises and ecological environment smooth, we had to join the ranks go. What are the advantages compared to ordinary low nitrogen gas boiler boiler advantage of low nitrogen gas boiler products mainly in the following aspects:? 1 condensing technology to reduce harmful emissions of harmful substances carbon dioxide and nitrogen oxides and condensation in condensing flue heat recovery tail water generated corresponding acid binding, and with the condensed water is discharged, so that harmful components carbon dioxide and nitrogen oxides in flue gas is further reduced, a region up to the national standards, in line with development of national environmental policies. 2. Installation convenient, easy routine maintenance of post-installation site and system maintenance no special requirements, external flue gas recirculation structure only increased circulation flue pipe to the burner, by simply connecting to; adjusting the air volume control section, filtered the process provided in the burner means; field installation to ensure reliable insulation and fixing, provided a bottom drain water outlet conduit; routine maintenance no difference with the standard product. 3. The Structure of Scientific boiler heat is efficient boiler special structure to ensure adequate gas back recycling space. The furnace volume heat load control within reasonable limits, for a variety of types of combustion. Smoke tube arrangement optimization to solve problems flue gas recirculation flow rate of the flue gas caused the increased flue gas volume, gas resistance and no significant increase in the standard comparison product. Larger water volume design, fluctuations in boiler load insensitive. Boiler water level stable, further reducing the probability of combustion instability. 4. Remote Monitoring Intelligent Expert System to provide protection for the safe operation of the boiler.
Electric heating condensing hot water boilers ecomfort Products: electric heating hot water boiler consists of furnace, electronic control box and a control system. Electric heating boilers as a new type of boiler equipment, environmentally friendly, clean, no pollution, no noise, automation, etc., with the sharp rise in prices of energy and reduction, more attention has been paid. Electric heating tube is the core component of the electric heating boiler, which directly determines the life of the boiler. Chosen as non-metallic electrical heating tube (such as a ceramic heating pipe), because it has a load resistance, long service life, the hydraulic separation structure, and the boiler does not leak.