gas dual fuel fired thermal oil boiler price
6 tons adjusting a combustion gas steam dual fuel fired thermal oil boiler price, normal combustion boiler three basic aspects of indicators include a uniform supply of the fuel, reasonable ventilation, adjustment the combustion. 1, to maintain the high temperature of the combustion chamber temperature of the upper layer is preferably in the 1100 ~ 1300 ℃, flame orange in color. Flame reddish color indicates that the amount is not enough to the wind, the color white indicates that excessive wind. It should be appropriately adjusted. 2, fuel ash to reduce ash content in the combustibles to be below 10%. 3, reducing the temperature of the boiler flue gas exhaust gas temperature should be controlled below 200 ℃. 4, holding furnace negative excess air boiler is 1.2 to 1.4, by adjusting the balance of the blowers to maintain the furnace pressure is -20 ~ -30Pa. 5, the thermal efficiency of the boiler to improve the thermal efficiency of the boiler should be kept above 60%. II. Combustion Adjustment 1, the amount of fuel to air required for combustion and the amount of a reasonable distribution. Ventilation should first increase the amount of fuel increases, it should first reduce the amount of fuel supply reduced ventilation. 2, the thickness of the seam and seam thickness configuration grate speed is 80 ~ 120mm grate speed at high, middle and low profile configuration of several commonly used methods:. 9a rapid combustion of thin seam b c thick seam in low combustion. 3 thick seam combustion speed, the segment with the wind blowing principle: burn promoting intermediate ends. That is, after the coal into the coal starts to warm up the shutter, fire line front arch, the primary combustion zone, the middle grate to burn the rear grate zone. Normal combustion conditions are: fuel from the coal at the beginning of the fire shutter 300mm, uniform flames, the fire bed formation, at the end of combustion from the end of the grate 300 ~ 500mm. 4. maintain proper furnace temperature to avoid coking. The fire bed to maintain the homogeneous combustion, to avoid burning fire bed obliquely. 6. The residence time of the fuel on the grate in less than 30 minutes.
Our business-to-steam dual fuel fired thermal oil boiler price produces steam attaches great importance to the quality of good or bad, it will indirectly determine the quality of our food is produced dates. The fact that we choose fast boiler is correct. We are very grateful to our fast boiler manufacturing plant in a short time, installation and commissioning of these two steam boilers, advance our production line went into operation. --customer feedback
Coal-fired dual fuel fired thermal oil boiler price gas conversion costs budget analysis
Under pressure "atmosphere 10" The premise of the policy and the current environmental situation of coal to gas expansion work is now in full swing up. So the transformation of the capital budget for gas fired boiler is how to conduct it? This is basically the transformation of the former coal-fired boilers for each client during prepared to do the necessary work. And today we talk about making a few parties need to pay attention when gas fired boiler reconstruction budget
Gas fired dual fuel fired thermal oil boiler prices into boilers which benefit: the traditional coal-fired steam boiler in the use of the process releases large amounts of carbon dioxide, sulfur dioxide and other harmful gases, causing serious air pollution and acid rain, and coal are non-renewable resources, Earth the storage capacity is limited, and the price of coal is relatively high with the successive implementation of the national policy of reform coal, coal-fired boiler traditional high pollution and high consumption market gradually been criticized, many provinces and cities have started from coal to gas work, namely the traditional coal-fired boilers to become clean non-polluting gas boilers, and strive to achieve the unity of economic and social benefits. In conventional coal-fired boilers used in the process releases large amounts of carbon dioxide, sulfur dioxide and other harmful gases, causing serious air pollution, and acid rain, while the coal are non-renewable resources, the limited storage capacity on the earth, and the price of coal is relatively higher, therefore, imperative coal to gas has the advantage.