hot water wall hung gas condensing boiler
6 tons gas steam hot water wall hung condensing boiler steam pressure adjusting a boiler operation, must frequently monitor the pressure gauge indicated. To maintain stable steam pressure, boiler pressure must not exceed the design pressure. Second, increasing boiler load: Steam pressure decreased boiler load is increased, if the level is high at this time, the amount of water should be reduced to a water supply or suspend, the amount of coal and increase the air volume. Gradually increase the amount of water at the same time to strengthen the burning, keep the steam pressure and the water level is normal. Third, the boiler load reduction: the vapor pressure rises to reduce boiler load, if the level is high at this time, the amount of coal should be reduced and the air volume, reduced combustion. Then the appropriate water reduction or suspension of water supply to the water vapor pressure and stability in the nominal range. Then press the normal combustion and the amount of feed water 8 to adjust. If the actual water level within the boiler is low, to increase the amount of water should, until the water level returns to normal after the combustion and needs to be adjusted according to the water vapor pressure and load changes.
Fire tube steam hot water wall hung condensing boiler manufacturer in Germany
Fire tube steam boiler that is the flue gas generated after the combustion of the fuel flows through the fire tube or the tobacco pipe, and heats the water, steam or steam-water mixture outside the fire tube or the smoke pipe, has developed many years in Germany, the technology is ripe, fire tube steam boiler from ZG fuel is gas or oil, for example natural gas, city gas, light oil, heavy oil, diesel oil, and so on. For the Environmental, fire tube steam boiler is supported by Government and enterprise.
Chongyang County, Hubei Province since the second half of 2015 to carry out the work out of small coal-fired hot water wall hung condensing boilers, non-New 20 tons of steam / hour and below the coal-fired boilers, the full implementation of small coal-fired boilers out of work, with environmental protection, Development and Reform Commission, by letter and other related sector wages, work to strengthen the efforts to promote thorough investigation of strict control to ensure that the county's non-compliance of small coal-fired boilers have all been eliminated remediation. In the specified date (June 30, 2017) completed the small coal-fired boilers out of the task before. Up to now, Chongyang County is not a new coal-fired boilers.
It is understood that, recently, joint quality supervision department of Chongyang County People's Government of Hubei Province, a special selection of personnel to carry out "looking back" activities for the phasing out small coal-fired boilers, special personnel division of responsibilities is based on special teams, focus on examination paper, under chemicals, wine, agriculture, and several other sectors and enterprises of boiler equipment, non-small coal-fired boilers happen "resurgence" phenomenon.
Gas-fired steam hot water wall hung condensing boiler which in modern industrial production, although the boiler very prominent role played by the choice of cleaning agent, but it is also very easy to scale boiler is subject to corrosion or damage. Gas boiler steam heater in such a situation therefore requires timely associated boiler equipment for cleaning, and performance of the practical utility of the most prominent non-gas-steam cleaners which is none other than this. Where a new gas heating system to replace the steam pipe cleaning agent must be used to eliminate the inner wall of debris so as not to affect gas-steam heat transfer efficiency and service life. It should be carefully checked, in use, to prevent water, acid, alkali and leakage into the low boilers using the system, and to install the filtration device, to prevent mechanical debris into the system to ensure the purity of the oil. A gas-steam with hot brands and process requirements, the correct selection of various grades of high-temperature gas-steam, and strictly abide by the provisions of the "organic heat carrier furnace Safety Technology Supervision" in the proper use of gas steam. Gas steam boiler at a high temperature gas for gas steam, gas, fuel furnace as a carrier, electric heating reactor and other heating devices, shall have the expansion tank and the oil sump and other security components and temperature control instruments and other facilities, to ensure safe operation. Purpose cleaners gas steam boiler is effectively rapid clearance gas steam boiler and the heat exchanger internal conduit accumulated soot and grease. Then we also have requirements on the cleaning agent, must not harm our metal heat transfer surface, requiring no residue, is completely dissolved, it must be easy to operate and requires only the use of the process in accordance with the needs of ordinary people to operate. Requires us on the gas boiler steam oven cleaners are: low energy environment, Wudu tasteless, non-flammable, irritation, can be directly discharged after cleaning.