jk cement boilers in mudhol project of mtech
Daily Maintenance of environmental protection and efficient gas steam jk cement boilers in mudhol project of mtech steam boiler gas are the main features of recent years because the state put forward higher requirements for environmental protection, many companies have purchased after rectification gas steam boiler, which allows gas steam boiler It has been more widely used, usually purchased with the strength of the manufacturers of the products, can use more secure stability, but also the stability of gas steam boiler and routine maintenance have a great relationship, here to introduce the gas steam boiler routine maintenance methods. First, the number of regular precipitation material will appear in the combustion chamber after long-term use of clean gas steam boiler the most practical, long-term accumulation of these deposits, is likely to cause instability phenomenon appears to run gas steam boiler. Thus every consumer should be a fixed time necessary for its complete cleaning, the use of high contamination factor in some environments, for periodic cleaning time shortened. Second, prevent bump gas steam boiler should not move it after installation, to prevent the move will lead to the internal components of the boiler loosening phenomenon. And during the move, the phenomenon is likely to occur and other items bump, although the product design anti-bump when will production, but severe shock and vibration inevitably will not have a serious impact on the internal boiler, boiler failure cause overhaul and had to stop production. Third, to avoid corrosion gas steam boiler must avoid being exposed to, once the boiler corrosion, which severely shortens the life and aesthetic appearance of the gas steam boiler corrosive materials, and therefore do not always pay attention to the corrosive Item close gas steam boiler, chemical cleaning agents are also used in cleaning corrosive cleaning. These are gas steam boiler easy to use method of routine maintenance, gas steam boiler does not require particularly careful care under normal circumstances, but about every six months to do some thorough cleaning is very necessary, in addition, if not compelling, do not move them, to prevent inflicting damage to the bump, with the article followed by contacting corrosive and do not let the gas steam boiler.
Gas-fired steam jk cement boilers in mudhol project of mtech ajar quick opening valve below the company's Henan fast boiler with small series to introduce gas steam boiler ajar quick opening valve. Gas steam boiler is the use of a steam boiler heated by a gas burner. Principle gas steam boiler: steam boiler with natural gas, liquefied petroleum gas, fuel gas such as city gas as fuel, the combustion in the furnace heat put out by heating the pot water, and allowed to vaporize into steam energy conversion device. Gas steam boiler before opening the valve to open slowly, the quick opening valve slightly open, after full preheating pipe. For better results the sewage, can switch several quick open valve. After discharge, turn off the quick opening valve, then slowly open the valve is closed, and finally open about fast opening valve between two valves to put water in the net. Sewage Note: ① first furnace before the sewage water is adjusted to higher than normal water levels to strictly monitor the water level of sewage, to prevent the boiler water shortage due to pollution caused. From time to time between the sewage, sewage pipes by hand after touching drain valve to test for leaks, such as feeling hot, indicating the drain valve leaks, the reasons should be identified to eliminate them. ② "diligence row, row of small, uniform discharge" principle, sewage class at least once, all the sewage outfall have to take turns, to prevent the deterioration of water quality and sewage pipes clogged furnace, and even cause damage to the water cycle and burst steward.
Rated evaporation 20 tons of gas steam jk cement boilers in mudhol project of mtech is 20t / h, the first time for the heating steam 20 minutes, very quickly.
20 tons of gas steam boiler has the following characteristics:
1, the condensing boiler technology advanced, the potential for secondary flue gas heat absorption, and more energy-saving effect is significantly higher thermal efficiency;
2, water treatment, water pumps, valves and other auxiliary instruments disposed are famous manufacturers of equipment, the quality and after-sales are guaranteed;
3, boiler control systems for the fast boiler self-developed PLC touch screen controller, intelligent control of boiler, more flexible;
4, the boiler overall total of more than 10 monitoring probes for water level, pressure, temperature has a clear control, once the abnormal failure, the alarm system starts immediately, fireman timely reminder to troubleshoot the situation.
Our hospital requirements for environmental protection, health and safety in these areas is very high, for a wide variety of market jk cement boilers in mudhol project of mtech is also very headache and confusion, there fast boiler solve the above problem, the boiler set clean environment to provide for our hospitals and efficient operation in one, coincides with the philosophy of our hospital. --customer feedback